TY - JOUR ID - TI - THE EFFECT OF INLET PRESSURE ON STEAM FLOW BEHAVIOR ACROSS A CONVERGENT-DIVERGENT NOZZLE تأثير الضغط الداخل على سلوك جريان البخار عبر فوهة متقاربة متباعدة AU - Hussein W. Mashi حسين وهيب ماشي AU - Arkan Kh. Al-Taie أركان خلخال حسين الطائي AU - Mohammed M. Al-Kafagy محمد مهدي صالح PY - 2015 VL - 8 IS - 3 SP - 267 EP - 283 JO - Al-Qadisiyah Journal for Engineering Sciences مجلة القادسية للعلوم الهندسية SN - 19984456 24117773 AB - Convergent-Divergent nozzle has many applications especially in steam turbine. The aim of this work is to see the effect of varying inlet pressure on steam behavior through the C-D nozzle. This was done experimentally and numerically. In the experimental part, a C-D nozzle was designed and fabricated in a test section. Steam was fed from boiler at range of (0.69-0.36) bar at saturation temperature for each pressure. Shadowgraph optical method was used to see the formation of shock waves and condensation zone. In the numerical part, the nozzle was simulated using FLUENT under ANSYS code 15.0. In the experimental results, it was found that the most important influence of rapid condensation on the pressure distribution is occurred downstream the through area, when the flow in the divergent part is termed supersonic the heat release causes a pressure rise in the zone of rapid condensation. Shock wave appears in the divergent part due to over-expansion. Each of condensation zone and shock wave were showed by using shadowgraph optical method. In the numerical approach, droplet growth rate contour are presented. The maximum droplet growth rate is (1020 micron /sec) and occurred downstream the throat area. The comparison of experimental and numerical results show good agreement

الفوهة المتقاربة المتباعدة توجد في الكثير من التطبيقات خصوصا في التوربينات البخارية. الهدف من هذا العمل هو ان نرى تأثيرتغيير الضغط الداخل على سلوك البخار خلال فوهة متقاربة متباعدة. - وقد تم ذلك عمليا ونظريا. في الجزء العملي، تم تصميم فوهةمتقاربة متباعدة - 9( بار وبدرجة حرارة التشبع لكل - ... 9.. ووضعت في قسم الاختبار. البخار يجهز من المرجل وبمعدل من ) 0ضغط. تم استخدام التقنية البصرية ) Shadowgraph ( لرؤية تشكيل موجات الصدمة ومنطقة التكثيف. في الجزء العددي، تمت محاكاةالفوهة باستخدام فونت انسز. في النتائج العملية، تبين أن أهم تأثير التكثيف السريع على توزيع الضغط في منطقة ما بعد الخنق ، عندمايتم يكون الجريان في الجزء المتباعد أسرع من الصوت يحدث فقدان للحرارة يسبب ارتفاع الضغط في منطقة التكثيف السريع . تظهرAl-Qadisiyah Journal For Engineering Sciences, Vol. 8……No. 3 ….2015268موجة صدمة في الجزء المتباعد بسبب الإفراط في انخفاض الضغط. وقد أظهرت كل من منطقة التكثيف وموجة صدمة باستخدامأسلوب بصري صورة شعاعية. في الجزء العددي، يتم عرض توزيع معدل نمو القطرات. الحد الاقصى لمعدل نمو القطرة هو ) 0909ميكرون / ثانية( وحدثت عند منطقة الخنق. المقارنة بين النتائج العملية والعددية تظهر توافق جيد. ER -