TY - JOUR ID - TI - Study of the Thermal Insulation Properties of the Compressed Earth Block Stabilized with Gypsum دراسة خاصية العزل الحراري للطابوق الترابي المضغوط المثبت بالجص AU - Lizan Ahmed Salih Zangana1, Aomed Ahmed Mohammed Tokmachy2 ليزان أحمد صالح زنكنة1، أوميد أحمد محمد التوكمجي2 PY - 2019 VL - 14 IS - 1 SP - 241 EP - 251 JO - Kirkuk Journal of Science مجلة كركوك للعلوم SN - 30054788 30054796 AB - One of the innovative ways that has been widely used in the last few decades is the production of compressed stabilized earth block with low cost and environmentally friendly. The current study aimed to study the geotechnical specification's for compressed stabilized earth block that were produced from earth materials for deposits of injana formation which were gathered from three different locations near Kirkuk governorate. A mix of soil samples were prepared in order to make a good soil mixture of 82% of sand and 17.43% of fine materials that include each of clay and silt to manufacture and produce compressed earth block. Then 15% of Paris plaster was added to the prepared soil mixture for the compressed stabilized earth block production, and then the wet soil mixture manually blended and compacted by manual press which is globally known as CINVA-RAM exerting high pressure by 17.2 MPA to produce all soil block samples. Then the blocks were cured naturally at room temperature for 28 days in order to undergo thermal insulation test. Based on the results it was concluded there is a close relationship between each of moisture content and the ability of thermal conduction for each block, in the sense that as it quickly loss water as the thermal insulation decrease and as it slowly loss water the thermal insulation increase, were the less value (0.005 W/Mk) of thermal conduction is recorded in block samples produced from the mixture soil which in turn is inversely proportional with thermal insulation.

من الطرق المبتكرة والتي تم اعتماد استخدامها بكثرة خلال العقود القليلة الماضية هي انتاج طابوق ترابي مضغوط ذي كلفة واطئة و صديقة للبيئة. وقد هدفت الدراسة الحالية الى دراسة الخصائص الجيوتكنيكية للطابوق الترابي المضغوط المثبت التي تم انتاجها من المواد الارضية لترسبات تكوين انجانة التي تم جمعها من ثلاث مواقع مختلفة بالقرب من محافظة كركوك. تم إعداد مزيج من نماذج تربة منطقة الدراسة لتشكيل خليط جيد من التربة بنسبة 82% من الرمل و17.43% من المواد الناعمة التي تشمل كل من الغرين والطين لتصنيع وانتاج الطابوق الترابي المضغوط المثبت. ثم تم اضافة الماء بنسب متدرجة تصل الى 15% و فيما بعد تم اضافة 15% من الجص لمزيج التربة المهيئة لانتاج الطابوق الترابي المضغوط، وتم خلط مزيج التربة الرطبة وكبسها يدويا بواسطة مكبس يدوي والذي يعرف عالميا بأسم CINVA-RAM الذي بدوره قادرعلى تسليط اكبر ضغط ممكن والذي يقدر بحوالي 17.2 ميكاباسكال لانتاج جميع نماذج الطابوق. ثم تم تجفيف جميع نماذج الطابوق المنتج تجفيفا طبيعيا و بدرجة حرارة الغرفة لمدة 28 يوم لاجل اخضاعها لفحص العزل الحراري. ووفقا للنتائج المستحصلة من فحص العزل الحراري، تم الاستنتاج بأنه يوجد علاقة وثيقة بين كل من المحتوى المائي وقابلية التوصيل الحراري للطابوق الترابي، اذ تبين بأنه كلما كان الطابوق الترابي سريعا في فقدان الماء كلما كان ذو عزل حراري اقل والبطئ في فقدان الماء يكون ذو خصائص عزل حراري اعلى، حيث ان اقل قيمة للتوصيل الحراري سجلت في نماذج الطابوق المنتج من التربة الخابطة والتي بلغت (0.005 W/mk) والذي بدوره يتناسب عكسيا مع العزل الحراري. ER -