TY - JOUR ID - TI - Flotation Method for Selective Separation of Lead and Zinc from Simulated Wastewater طريقة التعويم للفصل الانتقائي لعنصري الرصاص والخارصين من المياه الملوثه AU - Ahmed Abed Mohammed احمد عبد محمد AU - Saba Waleed kadhem صبا وليد كاظم PY - 2013 VL - 19 IS - 5 SP - 550 EP - 561 JO - Journal of Engineering مجلة الهندسة SN - 17264073 25203339 AB - In this paper flotation method experiments were performed to investigate the removal of lead and zinc. Various parameters such as pH, air flow rate, collector concentrations, collector type and initial metal concentrations were tested in a bubble column of 6 cm inside diameter. High recoveries of the two metals have been obtained by applying the foam flotation process, and at relatively short time 45 minutes . The results show that the best removal of lead about 95% was achieved at pH value of 8 and the best removal of zinc about 93% was achieved at pH value of 10 by using 100 mg/l of Sodium dodecylsulfate (SDS) as a collector and 1% ethanol as a frother. The results show that the removal efficiency increased with increasing initial metal concentrations in the alkaline conditions while it decreased in the acidic condition. Increasing air flow rate up to 1000 ml/min enhanced the separation efficiency. Selective flotation experiments were also conducted in the presence of metal ion mixture solutions. It was possible to separate lead and zinc under suitable condition, successful removals reached about 84% and 81% for lead and zinc respectively . It was observed that the first order equation fitted the data as good and better than any of the other equations.

طريقه التعويم انجزت لتحقيق فصل عنصري الخارصين والرصاص من المياه الملوثه ولقد تم دراسه العوامل التي تؤثرعلى عمليه الازاله وبالتالي كفاءه الفصل هذه العوامل تتضمن الداله الحامضيه ,تصريف الهواء, تركيز الخارصين, تركيز الرصاص, تركيزالماده الخافضه للشد السطحي ونوعها وايضا تاثير اضافه ملح الطعام. ولقد تم الحصول على كفاءات عاليه في استرجاع العنصرين باستخدام طريقه التعويم وبوقت قصيرنسبيا 45 دقيقه. النتائج اعطت 95% استرجاع لعنصرالرصاص في داله حامضيه مقدارها8 و93% استرجاع لعنصرالخارصين تم في داله حامضيه مقدارها 10 باستعمال SDS كماده خافضه للشد السطحي واستخدام 1%ايثانول كعامل مساعد. النتائج بينت ان زياده التركيز الاولي للعناصر يزيد كفاءه الازاله في الوسط القاعدي ويقللها في الوسط الحامضي .وقد وجد ان زياده تصريف الهواء الى 1000 ml/min يزيد كفاءه الازاله .تجارب التعويم للفصل الانتقائي ايضا تم مناقشتها بوجود محاليل خليط ايونات المعادن حيث من الممكن فصل الرصاص والخارصين تحت ظروف ملائمه بكفاءات 84% و81% للرصاص والزنك على التوالي .وقد وجد ان معدل ثابت الانتقال من الدرجه الاولى. ER -