TY - JOUR ID - TI - The Effect Of Tigris River Water Salinity On Corrosion Resistance Of Low Carbon Steel (St37) تأثير ملوحة مياه نهر دجلة في مقاومة التآكل للفولاذ منخفض الكربون(St37) AU - Azhar Abd Al-Hassan Ibrahim إزهار عبد الحسين إبراهيم AU - Ikhlas Ahmed Abd Al-Razak اخلاص احمد عبد الرزاق AU - Siham Hussein Ibrahim سهام حسين إبراهيم PY - 2013 VL - 17 IS - 5 SP - 1 EP - 9 JO - Journal of Engineering and Sustainable Development (JEASD) مجلة الهندسة والتنمية المستدامة SN - 25200917 25200925 AB - The aim of this work is to study the effect of Tigris river water salinity on the corrosion resistance of low carbon steel (St37). Water samples were collected from four location in Baghdad city (Towitha, Doraa, Bab - Alshrke and Bab- Almouadem ), some chemical properties were measured and its quality were classified. Specimens were prepared in dimensions of (1.5 X 1.5 X 0.5 cm) according to ASTM G71-31.Corrosion tests were investigated by electrochemical potential state cell where the test specimen represents the positive electrode (anode) while standard calomel electrode (SCE) represents the cathode, the voltage was determined by open circuit and compared with the positional of metal in the electrochemical series it is found equal to (-0.44volt) then voltage was increased ±100 mv, at each 10mv increasing the current was registered, the cathodic and anodic behavior drawn as curves the slopes of them represented by a line of interaction which will represent the corrosion current, then corrosion rate calculated by Tafel equation. The results of corrosion test showed that the river water from Bab – Almouadem area (with salinity 983 µs⁄m at 25 Co( gives the highest corrosion rate because of the high percentage of chloride in comparison with another waters also increasing in the dissolved oxygen which combined with iron to form iron oxide, while the other areas give very close values of corrosion rate.

نفذ هذا البحث لدراسة تأثير ملوحة مياه نهر دجلة في مقاومة التآكل الكهروكيميائي لفولاذ منخفض الكربونSt37 ، جمعت كميات من مياه نهر دجلة من أربعة مناطق مختلفة في مدينة بغداد هي (التويثة والدورة والباب الشرقي وباب المعظم) وقدرت فيها بعض الصفات الكيميائية وتحديد نوعيتها، استخدمت عينات من الفولاذ منخفض الكاربون St37 بالإبعاد x 1.5 x1.5 cm 0.5وفق المواصفة القياسيةASTM G71-31 . اجري اختبار التآكل كهر وكيميائي للمعدن بطريقة المجهاد الساكن بإمرار تيار كهربائي في خلية تتألف من قطبين أحداهما عينة الاختبار والثاني قطب من الكالوميل القياسي عند جهد (0.44- فولت) حدد من دائرة مفتوحة حسب موقع المعدن في السلسلة الكهروكيميائية، بعدها تم زيادة الجهد الى (±100 ملي فولت) حيث تم قراءة التيار عند كل10 ملي فولت ورسم العلاقة بين الجهد والتيار ومن نتائج السلوك الكاثودي والانودي واللذان تم تمثلهما بمنحنين. رسم مستقيمان يمثلان ميل هذه المنحنين وان نقطة تقاطع المستقيمان تمثل قيمة تيار التآكل الذي يؤدي إلى تغيير في الجهد واعتمادا على معادلة تافل تم احتساب معدل التآكل. أوضحت نتائج اختبار التآكل بأن أعلى معدل للتآكل كان في الوسط الذي يمثل الماء في منطقة باب المعظم( ذو ملوحة 983 µs⁄m عند درجة 25 oC ) لوجود نسبة كلوريدات أعلى من معدلاتها في المياه الأخرى إضافة إلى ارتفاع كمية الأوكسجين المذاب فيها، والذي يؤدي الى تكون الصدأ الناتج من اتحاد الأوكسجين مع الحديد. في حين أظهرت نتائج التآكل في المناطق الأخرى معدلات تآكل متقاربة. ER -